Off-road vehicles due to poor driving conditions, often installed off-road vehicle winch as a self-help device. When the car wheel deep into the special relief of the soil, or in the ice on the road can not travel, and fall into the hinge deep pit, you can use their own twist to the end of the rope fixed in the vicinity of reliable position. Driven by the engine winch coil twisted rope to make the car out of the woods.
See also can use it to rescue other troubled vehicles.
General Fromwinch atv synthetic winch rope mainly by the power box, drive shaft, winch, reducer, drum Jane and automatic brakes and accessories and other components.

How to use the winches with a winch to drive the crash vehicle

First of all, according to the situation of the vehicle and the terrain in Fromwinch 12Volt electric winch the conditions, choose a good place to rescue the car parked, tighten the hand brake, and then use the triangle wood before and after the wheel tight. Second, adjust the direction of the wheel of the vehicle, the direction of the twist is twisted, if necessary, can be dug rut, and then dragged. If you are limited by terrain or winch power is insufficient, you can use the pulley to change the direction of force, increase the traction, twist, in the traction can not stand around, such as the rope is loose or other abnormal circumstances, should immediately stop the parking check to prevent have an accident.

Traction manual winch - type shot - down machine operation mode

(1)Fromwinch tungsten4x4 winch movement of the cable traction winch-type fuel injection machine with the spray gun car installed together, when the pressure water through the hydraulic drive device to drive the winch car rotation, winding anchor anchored in the ground, holding The hose is sprayed
(2) winch fixed cable trailing plate-type cough irrigation machine was anchored in the ground, the channel steel tractor gun, drag the hose for spraying operations, a few days ago the application.

Fromwinch electric crane winch walking wheel brake device is a manual expansion brake, the installation of the winch wheel walking wheel wing inside. At the time of the chase, the device manipulates the handle so that the handle can be braked immediately when it is downhill or emergency in the seat of the tractor driver. Control walking speed or avoid accidents. Start spraying operation. And then put the handle on the winch car, and make the Fromwinch 3000lbs atv winch car walking wheel in the brake expansion situation. Then the winch car on both sides of the brake support down the anchor, so you can guarantee winch-type fuel injection machine spray operation stability

Use drum reels to enhance the power of the winch

Take a look at the power of the winch itself. It is known that the winch works by roping around a reel. The rope is pulled from the reel and attached to the object to be fixed. If you pull the rope slightly longer than the required length, it is easier to work.
Because this can reduce the diameter of the rope group, the motor under the same conditions to increase tension.
Even if the diameter of the drum is the same, the effective diameter of the drum varies with the length of the rope wound around the drum. Rope length is not the same, it will produce different power Fromwinch electric towing winch. When using the winch, it is best to pull most of the rope around it. But if all the rope is pulled out, it may cause the rope to fall off the reel. It is therefore best to leave three to five turns on the drum.

Everybody's car Fromwinch 12Volt electric winch since installed may not have not removed to, and the necessary maintenance is rarely done. Now we are all imported winches, the quality is relatively reliable. But a period of time the maintenance is necessary Oh! Winch working environment is also very bad, the wind and sun count the general, flooding, overload operation is also common. The winch is generally used in emergency situations, if suddenly dropped chain, it is a headache. Even the crisis will be safe!

Fromwinch rhino hand winch is divided into two parts, with one side of the terminal is the motor part, the clutch lever is part of the mechanical gear. Motor part of the carbon brush need to focus on inspection, carbon brush wear and the strength of the spring. The figure in the spring due to water rupture, leading to winch does not work. TJM carbon brush holder is spent to find the Kung Fu, or else the whole winch will not take up.

The Fromwinch 9600lb electric winch is dangerous. To ensure that no one is injured, follow these steps:
Winches must be worn when the gloves are formed, as burrs are created on the ropes, resulting in deep cuts. It is best to wear a great grip boots to reduce the risk of people standing on the ground slipping.
When using ragged rope, do not ride on the rope, do not skip from the above.
Do not pull the rope, and do not use the rope as the use of inertial rope.
Some people in the winch rope, it is necessary to hand control on the dashboard or hood. If you take in hand, in case of loose fingers will cause harm.
Do not pull the hook into the guide. At least one meter away from the winch where the loose force, the hook fixed to the bumper.
Do not put the twist. Before you start the winch, make sure you have at least five turns on the drum to ensure that the rope has sufficient adhesion on the winch drum.
Put a piece of canvas in the middle of the noose, and if the noose breaks, it can prevent it from rolling back to the body and the human body.
When the winch, do not think of ways to roll back the noose. First things finished, and then release the rope re-roll good.
When the winch leaves everyone far away.
Be sure to use the traction hook or chassis on the rescue vehicle, or use the upper spring clip. If you must operate the vehicle when the vehicle is turned on, open the hood to prevent the rope from breaking.
3600 kg of winch should be able to provide enough power to drag four-wheel drive vehicles. Also need belt or climbing rope, buckle pulley and rope buckle.
The use of buckle pulleys will double the rated power of the winch and make the rescue operation safer. If the winch is not directly in front of a good direct fixed point, you can use the pulley to connect two fixed points to effectively bypass a corner. If you can not find the natural fixed point, you can fix the rope on the spare tire and then cover.
In order to avoid damage to trees, be sure to tie the rope near the roots. If only a small tree can be used, the rope should be tied to the bottom of a number of small trees. Not deep trapped in the vehicle, the general can be dragged directly out of another car. Fromwinch heavy duty synthetic rope winch vehicles should be linked to a low magnification gear, while the side of the twist slowly afterburner. Stuck the vehicle must also be linked to a low magnification of the l block, slowly afterburner to help rescue.
If this does not work, you should use the double-pulley method. Tie the buckle pulley to the jammed vehicle, and then pass the noose back here to the retractor of the vehicle where the drawworks are used. As with the front, while the reverse side of the winch, the vehicle is also part of the stuck to provide some power.
To remove the fallen trees, choose a strong place, such as stones or trees, and then belt and buckle pulley tied to the top. Tie the second pulley to the tree and tie the rope. So that the rope from the buckle pulley and through the use of winch pull the wheel stuck to make it out of trouble.
Overturned vehicles can also be linked to the buckle pulley tied over the car body. Rope around the law should try to ensure that the minimum damage to the vehicle to avoid the sharp parts and important parts.

Waterproof performance of Fromwinch electric winches for 4x4 from waterproof standards. International Industrial Standards Waterproof IP and Japanese Industrial Standards Waterproof JIS is very close and has the following ratings:
0 No protection
1 Anti-drip I-type Vertical drop of water droplets without harmful effects
2 Anti-drip Type II does not adversely affect water droplets falling in the 15 "vertical direction
3 rain type and vertical direction within 60 degrees within the rain without harmful effects
4 splash-type by any direction of the water splash without harmful effects
5 Ejector-type Arbitrary direction directly affected by water spray without harmful effects
6 Water-resistant type Any direction directly by the water jet will not enter the internal
7 Anti-soaking type Under the specified conditions even if immersed in water will not enter the interior
8 medium-sized submerged in a certain pressure of water for a long time can still use
9 Moisture-proof type It can be used as moisture under 90% relative humidity

Manual winch works and how to use

Fromwinch 5500lbs electric winch with automatic brake device, which makes the operation more secure. When the winch wire rope pulls the goods, and the winch reel remains fixed, the brake will automatically open employment. When a variety of rescue work is needed, the Fromwinch 9600lb electric winch is another option outside the vehicle winch. Its biggest advantage is that it can be portable, you can connect from any direction of the car.
Hand winch, also known as hand winch, is a mechanical appliance, which is by hand shake the winch drum to pull the goods. A gear-driven winch cable reel pulls the load by rotating a wire rope wound around it. Lightweight and firm, electroplated, pressed steel structure, the steel cable pulls the pulley propulsion unit through two default fork heads. These forks pull the cable in the forward mode of the winch, and are also an automatic braking system. The fork will automatically lock when the grip increases. Fromwinch electric clutch winch can also be used for lifting (lifting force for the drag force of about 65%).

Lubrication of electric winch

In order to lubricate the Fromwinch 12500lbs electric winch, you should first in the winch worm gear reducer shell into the 2 liters of oil tank or hair must be oil, after every 100 hours, the oil should be added to the oil plug, 500 hours should be Replace the oil once.
Every 500 hours, to the Fromwinch electric winches for 4x4 of the transmission chain to refuel once, remove the chain to be carefully cleaned with oil, wash the chain should be placed on the heating to 80-90 degrees of the mixed oil (60% butter, 40 % Graphite), until the cooling of the oil so far, the surface of the chain of excess oil removed after the end of its place back, adjust its tightness.

The reel for traction and hoisting is the main winch of the manual winch

In the whole working process, the tension of the steel wire rope on the main reel is changed, it should be the case of the main volume of the main roll, reel, ground skidding, semi-floating skidding or aerial ropeway set material, Tube on the wire of the various rally line analysis, to identify the maximum tension, so that the main barrel of steel wire traction to meet the needs of the maximum tension. According to the experience of the use of Fromwinch 4500lbs electrical winch, the main volume of steel wire Shao Shao's largest force, usually in the village to enhance the process; and the aerial ropeway, the cable type and erection of the line with the performance of the Fromwinch small suv winch is compatible, the main also reflect The wire rope tension at run time is now analyzed separately.

Key points for safe operation of electric winch

Fromwinch 4500lbs synthetic rope winch should be placed in the line of sight good, solid foundation, safe and open place. The position of the traction macro diverter pulley should be perpendicular to the center of the drum
Line, its distance is not less than 40 times the length of the reel, its height must exceed the wooden stack 2-3 meters, is strictly prohibited in the crib on the guide pulley.
    2. Operation to concentrate, and must not leave the post and found illegal operations into an insecure situation, immediately stop to correct, ground inspection, Levi
Repair, to ensure that the machine set up a solid dry, no damage to the rope.
    3. Multi-disturbance disassembling, pay attention to the Fromwinch competition car Winch machine security teachers to choose the election chips, are not allowed to overlap, cross operations, run-time, is strictly prohibited all personnel to enter the main set to turn
To the rope within the angle of the rope of the pulley, and away from the straight wire rope Io meters.
    4. Unloading the wire rope on the crimping machine, the tail is not allowed on the card, in case of need to release the rope, protection equipment.
    5. Traction wood resting, in case of floods can not be strong trailing hard lines, should be identified after the exclusion of obstacles and then traction, is strictly prohibited with a combination of rapid separation of the main clutch
Device to overcome the sudden increase in resistance.
    6. In the inspection and maintenance, and found the following circumstances one of the wire rope must be re-replaced or scrapped:
    (1) outside the home wear wire to wire diameter of one-half;
    (2) in a pitch within the number of broken wire 6-8 apply;
    (3) long-term use of wire rope, the elongation of 10% of the lamp
    (4) Where a strand of steel is broken,
    (5) wire rope with a dead end or serious corrosion.