Traction manual winch - type shot - down machine operation mode

(1)Fromwinch tungsten4x4 winch movement of the cable traction winch-type fuel injection machine with the spray gun car installed together, when the pressure water through the hydraulic drive device to drive the winch car rotation, winding anchor anchored in the ground, holding The hose is sprayed
(2) winch fixed cable trailing plate-type cough irrigation machine was anchored in the ground, the channel steel tractor gun, drag the hose for spraying operations, a few days ago the application.

Fromwinch electric crane winch walking wheel brake device is a manual expansion brake, the installation of the winch wheel walking wheel wing inside. At the time of the chase, the device manipulates the handle so that the handle can be braked immediately when it is downhill or emergency in the seat of the tractor driver. Control walking speed or avoid accidents. Start spraying operation. And then put the handle on the winch car, and make the Fromwinch 3000lbs atv winch car walking wheel in the brake expansion situation. Then the winch car on both sides of the brake support down the anchor, so you can guarantee winch-type fuel injection machine spray operation stability

Use drum reels to enhance the power of the winch

Take a look at the power of the winch itself. It is known that the winch works by roping around a reel. The rope is pulled from the reel and attached to the object to be fixed. If you pull the rope slightly longer than the required length, it is easier to work.
Because this can reduce the diameter of the rope group, the motor under the same conditions to increase tension.
Even if the diameter of the drum is the same, the effective diameter of the drum varies with the length of the rope wound around the drum. Rope length is not the same, it will produce different power Fromwinch electric towing winch. When using the winch, it is best to pull most of the rope around it. But if all the rope is pulled out, it may cause the rope to fall off the reel. It is therefore best to leave three to five turns on the drum.

Everybody's car Fromwinch 12Volt electric winch since installed may not have not removed to, and the necessary maintenance is rarely done. Now we are all imported winches, the quality is relatively reliable. But a period of time the maintenance is necessary Oh! Winch working environment is also very bad, the wind and sun count the general, flooding, overload operation is also common. The winch is generally used in emergency situations, if suddenly dropped chain, it is a headache. Even the crisis will be safe!

Fromwinch rhino hand winch is divided into two parts, with one side of the terminal is the motor part, the clutch lever is part of the mechanical gear. Motor part of the carbon brush need to focus on inspection, carbon brush wear and the strength of the spring. The figure in the spring due to water rupture, leading to winch does not work. TJM carbon brush holder is spent to find the Kung Fu, or else the whole winch will not take up.

The Fromwinch 9600lb electric winch is dangerous. To ensure that no one is injured, follow these steps:
Winches must be worn when the gloves are formed, as burrs are created on the ropes, resulting in deep cuts. It is best to wear a great grip boots to reduce the risk of people standing on the ground slipping.
When using ragged rope, do not ride on the rope, do not skip from the above.
Do not pull the rope, and do not use the rope as the use of inertial rope.
Some people in the winch rope, it is necessary to hand control on the dashboard or hood. If you take in hand, in case of loose fingers will cause harm.
Do not pull the hook into the guide. At least one meter away from the winch where the loose force, the hook fixed to the bumper.
Do not put the twist. Before you start the winch, make sure you have at least five turns on the drum to ensure that the rope has sufficient adhesion on the winch drum.
Put a piece of canvas in the middle of the noose, and if the noose breaks, it can prevent it from rolling back to the body and the human body.
When the winch, do not think of ways to roll back the noose. First things finished, and then release the rope re-roll good.
When the winch leaves everyone far away.
Be sure to use the traction hook or chassis on the rescue vehicle, or use the upper spring clip. If you must operate the vehicle when the vehicle is turned on, open the hood to prevent the rope from breaking.
3600 kg of winch should be able to provide enough power to drag four-wheel drive vehicles. Also need belt or climbing rope, buckle pulley and rope buckle.
The use of buckle pulleys will double the rated power of the winch and make the rescue operation safer. If the winch is not directly in front of a good direct fixed point, you can use the pulley to connect two fixed points to effectively bypass a corner. If you can not find the natural fixed point, you can fix the rope on the spare tire and then cover.
In order to avoid damage to trees, be sure to tie the rope near the roots. If only a small tree can be used, the rope should be tied to the bottom of a number of small trees. Not deep trapped in the vehicle, the general can be dragged directly out of another car. Fromwinch heavy duty synthetic rope winch vehicles should be linked to a low magnification gear, while the side of the twist slowly afterburner. Stuck the vehicle must also be linked to a low magnification of the l block, slowly afterburner to help rescue.
If this does not work, you should use the double-pulley method. Tie the buckle pulley to the jammed vehicle, and then pass the noose back here to the retractor of the vehicle where the drawworks are used. As with the front, while the reverse side of the winch, the vehicle is also part of the stuck to provide some power.
To remove the fallen trees, choose a strong place, such as stones or trees, and then belt and buckle pulley tied to the top. Tie the second pulley to the tree and tie the rope. So that the rope from the buckle pulley and through the use of winch pull the wheel stuck to make it out of trouble.
Overturned vehicles can also be linked to the buckle pulley tied over the car body. Rope around the law should try to ensure that the minimum damage to the vehicle to avoid the sharp parts and important parts.

Waterproof performance of Fromwinch electric winches for 4x4 from waterproof standards. International Industrial Standards Waterproof IP and Japanese Industrial Standards Waterproof JIS is very close and has the following ratings:
0 No protection
1 Anti-drip I-type Vertical drop of water droplets without harmful effects
2 Anti-drip Type II does not adversely affect water droplets falling in the 15 "vertical direction
3 rain type and vertical direction within 60 degrees within the rain without harmful effects
4 splash-type by any direction of the water splash without harmful effects
5 Ejector-type Arbitrary direction directly affected by water spray without harmful effects
6 Water-resistant type Any direction directly by the water jet will not enter the internal
7 Anti-soaking type Under the specified conditions even if immersed in water will not enter the interior
8 medium-sized submerged in a certain pressure of water for a long time can still use
9 Moisture-proof type It can be used as moisture under 90% relative humidity